Skip to main content
SUPERVISOR
Mahmood Monir-vaghefi,Ali Ashrafi
سيدمحمود منيرواقفي (استاد راهنما) علي اشرفي (استاد مشاور)
 
STUDENT
Hassan Heidari
حسن حيدري سورشجاني

FACULTY - DEPARTMENT

دانشکده مهندسی مواد
DEGREE
Master of Science (MSc)
YEAR
1395

TITLE

Investigation of the Process and Effective Parameters on Ni-P Electroless coating on Mild Steel Using Hot-source method
Investigating the Process Ni-P Electroless coating on Mild Steel Using Hot-Base Method. In the conventional method of electroless nickel-phosphorus coatings, the whole bath is heated and coated. In this research, the sample was heated in a low-temperature bath with a hot base method and the coating process of the samples was studied. Temperature and pH changes and its effect on coating morphology, deposition rate, hardness and roughness of coatings were studied. Also, the heat treatment and the determination of the abrasive properties of coatings in this study were investigated. The selected temperature range was hot in the hot base region of 130 to 190 ° C and pH was 3.6 to 5.2. It was found that the formation of nickel-phosphor electroless coating on the base of the hot base caused a significant increase in the deposition rate. The results of the study showed that in the hot base method, compared to the conventional electroless coating at pH, 5.2, the deposition rate has more than doubled. It was found that the increase in deposition rate also increases the roughness of the coating. Using the results of the hardness test, it was also found that increasing the temperature would increase the hardness of the coating, due to the decrease in the amount of phosphorus of the coating by increasing the temperature of the hot source. In the hot base method, it was possible to create a coating at lower pH levels. The high temperature of the hot source makes the coating at lower pH levels possible. Possibility of coatings at low pH, providing an electroless coating of phosphorous nickel-phosphorus. In this study, the coating was obtained at pH 3.6 and 3.2. Heat treatment studies of high-phosphorous coatings showed that the hardness of phosphorous coatings was higher than other coatings, so that the hardness of the coating after the heat treatment at a lower pH was higher than the high pH, which was due to an increase in the percentage of phosphorus, And the amount of phosphorous-nickel phases. The study of the abrasive properties of hot-dip coatings revealed that the coatings of the hybrid compared to single-layer coatings have better abrasion resistance.
بررسي فرآيند و تاثير پارامترهاي موثر بر پوشش دهي الکترولس Ni-P روي پايه فولاد ساده کربني به روش پايه داغ در روش مرسوم پوشش دهي الکترولس نيکل-فسفر، کل حمام را گرم مي کنند و اقدام به پوشش دهي مي نمايند. در اين تحقيق نمونه مورد نظر در حمام با دماي پايين به روش پايه داغ گرم شد و فرايند پوشش دهي نمونه ها مورد مطالعه و بررسي قرار گرفت. تغييرات دما و pH و اثر آن روي مورفولوژي پوشش، سرعت رسوب گذاري، سختي و زبري پوشش ها مورد مطالعه قرار گرفت همچنين عمليات حرارتي و بررسي خواص سايشي پوشش هاي ايجادي به روش پايه داغ در اين تحقيق مورد مطالعه و بررسي قرار گرفت. محدوده دمايي انتخابي در ناحيه پايه داغ 130 تا 190 درجه سانتي گراد و pH ، 3.6 تا 5.2 انتخاب گرديد. با بررسي هاي به عمل آمده مشخص شد ايجاد پوشش الکترولس نيکل–فسفر بر مبناي پايه داغ باعث افزايش چشمگير سرعت رسوب گذاري شده است. نتايج مطالعه نشان داد در روش پايه داغ نسبت به پوشش دهي الکترولس متداول در pH ، 5.2 سرعت رسوب گذاري به حدود بيش از دو برابر رسيده است. با بررسي هاي به عمل آمده مشخص شد که افزايش سرعت رسوب گذاري باعث افزايش زبري پوشش نيز مي گردد. با استفاده از نتايج حاصل از تست سختي سنجي نيز مشخص شد که افزايش دما باعث افزايش سختي پوشش ميشود، اين امر به خاطر کاهش ميزان فسفر پوشش با افزايش دماي منبع داغ است. در روش پايه داغ امکان ايجاد پوشش در pH هاي پايين فراهم شد. دماي بالاي منبع داغ باعث فراهم شدن پوشش دهي در pH هاي پايين شده است. امکان ايجاد پوشش ها در pH پايين، ايجاد پوشش الکترولس نيکل-فسفر با فسفر بالا را فراهم آورد. در اين پژوهش پوشش در pH برابر 3.6 و 3.2 نيز بدست آمد. بررسي هاي عمليات حرارتي پوشش هاي با فسفر بالا مشخص کرد که ميزان سختي در پوشش هاي با فسفر بالا بيشتر از پوشش هاي ديگر است بطوريکه سختي پوشش پس از عمليات حرارتي در pH پايين به مراتب بالاتر از pH بالا بود که به خاطر افزايش درصد فسفر، تعداد و مقدار فازهاي سخت فسفيد نيکل است. بررسي خواص سايشي پوشش ها ايجادي به روش پايه داغ مشخص کرد، پوشش هاي هيبريدي در مقايسه با پوشش هاي تک لايه داراي مقاومت به سايش بهتري هستند

ارتقاء امنیت وب با وف بومی